Characteristic studies on the mechanical properties of quarry dust …

2015. 9. 9.· was studied with various proportions of quarry dust (CM 1:3, CM 1:2, and CM 1:1). The experimental results showed that the addition of quarry dust for a fine to coarse aggregate ratio of 0.6 was found to enhance the compressive properties as well as elastic modulus. Key words: Concrete, quarry dust, fillers, elastic modulus, compressive strength.

Get Price

Analysis of Concrete Made from Quarry Dust - IJERT

2019. 7. 1.· concrete. Quarry dust is a byproduct that is generated from the ... (CS) and cement by-pass dust (CBPD) addition on concrete properties Results showed that 5% copper slag substitution for Portland cement gave a similar strength performance as …

Get Price

Studies on Quarry Dust as Partial Replacement of Fine Aggregates …

2017. 4. 30.· flexural strength. It was observed that the addition of quarry dust that would replace the fine material at particular proportion has displayed an enhancing effect on properties of concrete. This investigation proves that quarry dust can be used as a partial substitute for natural sand in preparing concrete. II

Get Price

Recycling of quarry dust for supplementary cementitious …

2020. 3. 20.· As for the cement based samples, the addition of quarry dust will increase the equivalent water content with respect to cement particle, which has been found to attribute to higher hydration degree of the cement. On the other hand, the fine quarry dust can provide additional nucleation sites for slag/cement hydration.

Get Price

High Performance Concrete using Quarry dust as Fine aggregate

2016. 2. 29.· quarry dust and addition of various percentage of steel fibre. Workability of quarry dust HPC decreases when compared to conventional HPC. With addition of super plasticizer workability of quarry dust concrete will increases. When adding steel fibre it reduces the workability of concrete. Table No. (4): Slump Value of various Mixes

Get Price

Partial Replacement of Sand by Quarry Dust in Concrete

2021. 6. 4.· investigated the partial replacement of sand with quarry dust. Initially cement concrete cube was studied with various proportions of cement concrete + quarry dust (M 20, AND M25). The experimental results showed that the addition of quarry dust as fine aggregate ratio of 30%, 40% and 50% was found to enhance the compressive properties.

Get Price

Study on Compressive Strength of Quarry Dust as Fine …

Figure 3. 5 The effect of quarry dust in coconut shell concrete The addition of coir by the weight of cement in coconut shell concrete is done in a study by (Ealias et al., 2014).It was recorded that the addition of coir decreases the tensile strength of coconut shell concrete for about 16%. In another study by (Shraddha et al., 2014), a same value of tensile strength is shown for both ...

Get Price

(PDF) Partial Replacement of Sand by Quarry Dust in …

Quarry dust can be defined as residue, tailing or proportions of cement concrete + quarry dust (M 20, AND M25). other non-voluble waste material after the extraction and The experimental results showed that the addition of quarry dust processing of rocks to form fine particles less than 4.75mm. as fine aggregate ratio of 30%, 40% and 50% was found to enhance the compressive properties.

Get Price

Sustainable utilization of Quarry dust and waste plastic fibers as a …

The split tensile strength of M30, M40 concrete also increases up to 50% replacement of natural sand by quarry dust and waste plastic up to 6%. The same slightly fall down if it is replaced 100%....

Get Price

[PDF] Characteristic studies on the mechanical properties …

Concrete plays the key role and a large quantum of concrete is being utilized in every construction practices. River sand, which is one of the constituents used in the production of conventional concrete, has become very expensive and also becoming scarce due to depletion of river bed. Quarry dust is a waste obtained during quarrying process.

Get Price

Partial Replacement of Sand by Quarry Dust in Concrete

2021. 6. 4.· proportions of cement concrete + quarry dust (M 20, AND M25). The experimental results showed that the addition of quarry dust as fine aggregate ratio of 30%, 40% and 50% was found to enhance the compressive properties. Index Terms-Sand, flash, quarry dust (QD), sieve analysis, slum cone test. Compressive test

Get Price

High Performance Concrete using Quarry dust as Fine aggregate

2016. 2. 29.· ABSTRACT² This paper describes the experimental study of High-Performance concrete with quarry dust as fine aggregate in addition of steel fibre. To over-come the difficulties due to excessive sand mining, quarry dust was used as fine aggregate. Quarry dust is the fine material, produced from gravel crushers.

Get Price

Studies on Quarry Dust as Partial Replacement of Fine Aggregates in Concrete

2017. 4. 30.· 1. Quarry dust can be used as a finer material which can reduce the voids in concrete. 2. Up to 20% replacement of fine aggregates by quarry dust, the results obtained are satisfactory. 3. From the above results 15% replacement of quarry dust gives high Compressive and Flexural Strength. 4. By using quarry dust wastes instead of conventional

Get Price

Introduction to Quarry-Dust as Partial Replacement …

2020. 5. 19.· In one more investigation where natural sand is replaced 100% with quarry dust to study the physical properties, mechanical properties and durability of concrete made by quarry dust with done by R. Ilangovana , N. Mahendrana and K. Nagamanib [7].Mix design has been developed for M20, M30 and M40 grade of concrete for both conventional concrete and quarry dust concrete using design …

Get Price

IMPACT OF QUARRY DUST & DOLOMITE POWDER ON COMPRESSIVE STRENGTH OF CONCRETE

2018. 6. 20.· ABSTRACT-The purpose of this work is to describe the effect of quarry dust and dolomite on the compressive strength of concrete. The present examinations indicate that dolomite may be used as partial replacement of cement in concrete and quarry dust may be suitably replaced with fine aggregate in concrete to some extent.

Get Price

“REPLACEMENT OF SAND BY QUARRY DUST IN CONCRETE”

2021. 5. 13.· Quarry dust has been proposed as an alternative to river sand that gives additional benefit to cement during construction. In areas where constructors use this dust, there is a significant reduction of air pollution by the dust. Quarry dust is very volatile and its inhalation can cause respiratory problems.

Get Price

Experimental Study on the Properties of Concrete with Replacement of Cement by Quarry ...

2019. 7. 1.· granite dust as cement addition. Finally a reduction in water cement ratio around 0.03 was enough to cancel the reduction in concrete compressive strength as a result of granite dust up to 15.0% as cement replacement. MATERIALS Quarry sludge Quarry …

Get Price

Study on Compressive Strength of Quarry Dust as Fine …

2016. 7. 28.· The concept of replacement of natural fine aggregate by quarry dust which is highlighted in the study could boost the consumption of quarry dust generated from quarries. By replacement of quarry dust, the requirement of land fill area can be reduced and can also solve the problem of natural sand scarcity. The availability of sand at low cost as a fine aggregate in concrete is not suitable and ...

Get Price

Research Paper STRENGTH AND DURABILITY STUDIES ON QUARRY DUST CONCRETE …

2016. 4. 19.· The test results show that the use of well graded quarry dust instead of sand along with admixture improves the strength of concrete. Further, the addition of inhibitors provides very good resistance against chemical attack and increases corrosion resistance. KEY WORDS: concrete, quarry dust, super plasticizer , corrosion resistance ...

Get Price

[PDF] Characteristic studies on the mechanical properties …

Corpus ID: 136919269. Characteristic studies on the mechanical properties of quarry dust addition in conventional concrete @inproceedings{Sivakumar2011CharacteristicSO, title={Characteristic studies on the mechanical properties of quarry dust addition in conventional concrete}, author={A. Sivakumar and M. Prakash}, year={2011} }

Get Price

Partial Replacement of Sand by Quarry Dust in Concrete

2021. 6. 4.· proportions of cement concrete + quarry dust (M 20, AND M25). The experimental results showed that the addition of quarry dust as fine aggregate ratio of 30%, 40% and 50% was found to enhance the compressive properties. Index Terms-Sand, flash, quarry dust (QD), sieve analysis, slum cone test. Compressive test

Get Price

THE EFFECT OF QUARRY DUST WITH CEMENT BY …

2018. 11. 19.· The numerous demanding application of concrete is not readily met with Ordinary Portland Cement (OPC) alone. To meet up the demand and as well as ensured the green concrete durability, it has becomes necessary to incorporate mineral additions with the best combination of others by-product as replacement to improve the performance without jeopardizing the strength of the concrete.

Get Price

Strength Properties of Concrete with Partial Replacement of Cement by Granite Quarry Dust

2019. 7. 1.· Granite dust cement replacement or addition of 5.0%, 7.5%, 10.0% and 15.0% were used. The test results showed an improvement on concrete compressive strength at 5.0% granite dust as cement replacement and improvement on compressive strength at most levels of granite dust as cement addition.

Get Price

IMPACT OF QUARRY DUST & DOLOMITE POWDER ON COMPRESSIVE STRENGTH OF CONCRETE

2018. 6. 20.· ABSTRACT-The purpose of this work is to describe the effect of quarry dust and dolomite on the compressive strength of concrete. The present examinations indicate that dolomite may be used as partial replacement of cement in concrete and quarry dust may be suitably replaced with fine aggregate in concrete to some extent.

Get Price

Studies on quarry dust as partial replacement of fine …

2017. 5. 5.· It was observed that the addition of quarry dust that would replace the fine material at particular proportion has displayed an enhancing effect on properties of concrete.

Get Price

high performance concrete using quarry dust as fine …

Download Journal Download Certificate. Kewords. Quarry dust, High performance concrete, Sand, Steel fibre, Silica fume. Reference [1]. ACI 211.4R-93 (Reapproved 1998), Codel provision. [2]. Anitha selva sofia.S.D, Gayathri.R and Swathi.G ‘Experimental investigation on quarry dust concrete with chemical admixture’, Int. Journal of Latest Research in Science and Technology, Vol-2, issue-2 ...

Get Price

“REPLACEMENT OF SAND BY QUARRY DUST IN CONCRETE”

2021. 5. 13.· Quarry dust has been proposed as an alternative to river sand that gives additional benefit to cement during construction. In areas where constructors use this dust, there is a significant reduction of air pollution by the dust. Quarry dust is very volatile and its inhalation can cause respiratory problems.

Get Price

Experimental Study on the Properties of Concrete with Replacement of Cement by Quarry ...

2019. 7. 1.· granite dust as cement addition. Finally a reduction in water cement ratio around 0.03 was enough to cancel the reduction in concrete compressive strength as a result of granite dust up to 15.0% as cement replacement. MATERIALS Quarry sludge Quarry …

Get Price

Research Paper STRENGTH AND DURABILITY STUDIES ON QUARRY DUST CONCRETE …

2016. 4. 19.· The test results show that the use of well graded quarry dust instead of sand along with admixture improves the strength of concrete. Further, the addition of inhibitors provides very good resistance against chemical attack and increases corrosion resistance. KEY WORDS: concrete, quarry dust, super plasticizer , corrosion resistance ...

Get Price